Geothermal Drilling Rig Model Water-46G

Drill2Water, LLC
Geothermal Drilling Rigs - Model Water-46G - 46 horsepower diesel

Keywords: water drilling rig, well drilling rig, geothermal drilling rig, water well drilling, water well drilling rig, drill water well, portable drilling rig, drilling for water, water well drilling equipment
for sale, skidsteer drilling rig, bobcat drilling rig, borehole drilling, portable water drilling rig, portable Water Well Drilling rig and Geothermal Drilling equipment. Complete water well or
geothermal drill rigs, drill pipe, drill bits, mud pumps, water swivel, Water well geothermal drilling rig,

LIMITED WARRANTY

Every reasonable effort is made to guard against defective material or workmanship entering
into the manufacture of products by Drill2Water, LLC. However in the event of failure or
defective part within 12 months of purchase, our entire liability is limited to the value of, or
replacement of such defective part within that period.   Manufacturers of components used
may have warranties in excess of 12 months which may or may not provide further coverage
beyond our coverage. Drill2Water, LLC expressively disclaims liability for incidental or
consequential damages. Any modification to the manufactured product not performed by
manufacturer or without manufacturers written consent voids any expressed warranty.
Drill2Water, LLC will not be responsible for bodily injury, loss of life, loss of revenue, or
property damage if such should occur in connection with the use of our product.   No warranty
is given on parts that are normally subject to rapid wear, such as packing, wash pipes, wear
bushing, stripper rubbers, springs, bearings, hydraulic hoses, chain, mud pumps, drill bits,
trailer brakes and tires, and hydraulic pumps. Seller’s total responsibility for any claims,
damages, losses or liabilities arising out of, or related to, all products covered there under
shall not exceed the purchase price of the parts.   A warranty claim shall be filed and the
defective item returned to Drill2Water, LLC at customers expense.

Loads into 20 ft standard shipping container with no disassembly required. If
an air compressor is also purchased a 40 ft container is required.

46 hp Portable Diesel Powered Trailer Mounted Water Well Drilling Rig
One diesel engine - All hydraulic powered

Model Water-46G
Mud/Air Capable Drilling Rig

Pricing begins with the Standard model Water-46G whose capabilities are
significantly increased depending on the additional Air Option # selected.

$ - Standard model Water-46G as described under 'Standard Equipment' below. Air
compressor not included.

Recommended Drilling Capacity:
Bore depth with Option #1, #2, or #3 air compressor (5" tricone bit): 225feet / 68 m
Bore depth with Option #1, #2, or #3 air compressor (5" hammer bit): 225 feet / 68 m
Bore depth with mud pump (10" bit): 225 ft / 68 m

Standard Equipment:
Engine:   Liquid cooled Kubota 46 hp diesel, electric start, glow plugs, with charging circuit
Engine monitoring: Hour meter, low oil shut down, high temperature shut down, RPMs
Fuel tank capacity:          Above deck 12 gallons with fuel level indicator

Hydraulic pumps:    Single or dual gear pump at 2500 psi or 3000 psi output
Hydraulic tank:     25 gallon with 10 micron filtration
Forced air hydraulic oil cooler installed:   Optional
Maximum Hydraulic output:          26.28 gpm at 2500 psi
Hydraulic valve stack:          Adjustable main pressure relief installed
Counter balance valve installed:    Yes
Downward pressure on drill bit fine speed feathering control: Yes
Hands Free Drilling: Yes

Drill rotation torque:        Top head - 5,838 inch pounds at 119 rpms at 2500 psi
Drill rotation fine speed feathering control: Yes

Swivel rating:     1-1/2" inlet / 750 psi / 5,870 lbs pulldown / 6,700 lbs pullback
Push or pull casing capable:          Yes, 10 ft sections

Mast lifting and lowering cylinder:          Yes
Downward pressure enabled:          Yes
Mast structure:          Rectangular tubing with 3/8" skid plate
Drill head Up/Down Drive system:     Hydraulic driven direct chain drive
Drill Pipe holding locks:          Yes
Hydraulic top joint pipe breakout option included:    Yes
Drill pipe: 210 feet (21 ten foot sticks) 2-3/8" Mayhew Jr

Mud pump:    2x3 hydraulic powered variable speed with suction line and foot valve.

Trailer specifications:
Length:          19 ft (228 inches) (varies depending on shipping location)
Width:             7' 0" (84 inches)
Weight:          +/- 5150 lbs
Trailer:   Custom manufactured 7' x 12' all steel 14,000 lb rated trailer with 12" I-beam
carriers and two 7000 lb axles.   Both axles equipped with electric brakes. Trailer has two
rear and one front screw type manual leveling jacks.   Trailer bed is expanded metal and plate
steel stitch welded to all steel cross members.    Trailer has built in drill pipe storage rack.
Trailer design may vary depending on the final shipping destination

Rig paint scheme color: White and black

Mast tower extension, swing away drill head, and casing winch is available:

Air Options:
$ - Standard model Water-46G with Air Option #1 includes standard Model Water-46G
with new towable 375 cfm @ 175 psi (12.07 bar) diesel powered air compressor, and
pulse adjustable hammer oil injector.

$ - Standard model Water-46G with Air Option #2 - Includes standard Model
Water-46G with new towable 650 cfm @ 200 psi (13.79 bar) diesel powered air
compressor, and pulse adjustable hammer oil injector

$ - Standard model Water-46G with Air Option #3 - Includes standard Model
Water-46G with new towable or skid mounted 700 cfm @ 365 psi (25.17 bar) diesel
powered air compressor, and pulse adjustable hammer oil injector.

Price and specifications subject to change without notice!